Monday 16 July 2012

Plumbing first fix and second hemp wall

My plumber Len made a great comment about the house "I like the design, but not for the plumber." The house had two bathrooms at opposite ends of the house and the kitchen is not near the bathrooms either. The town water connects to the house at the the opposite end to the water tank, and the toilets and washing machine are all connected to rainwater from the water tank. The water and LP gas pipes all run between the ceiling and roof and then down the walls, where possible they will run down the internal walls which are not hemp, but there are not many internal walls in the house.

The water pipes are all PEX (cross linked polyethylene), but where sharp bends are needed, such as going out  through the wall to the water tank, the pipes are copper. Len, my plumber, also lagged all the pipes that are going through the hemp walls. When I asked why he used the thick black lagging around the pipes, his reply was that he had it sitting around in his garage for a while, it being the type of lagging used on solar hot water systems, but when he ran out of the black he will use a thinner green lagging, like used for hot water pipes, for the rest of the pipes that go through the hemp walls.

Lagged pipes running through what will be a hemp wall
Pipes coming out through hemp wall to and from water tank
Gas (yellow) and hot and cold water pipes running to kitchen
While on site I also did a second test hemp wall. On further inspection the first test wall I did was slightly bowed out in the centre on one side. I am not sure if this was caused by the formwork being bowed or from over tamping. So for the second wall I checked the formwork was straight using a level as a straight edge and checked the wall as I put the hemp in to make sure the tamping did not bow the formwork. After the lesson of the first wall I also made sure that I tamped the corners and other areas around the spacers. The result was a better wall on my second test section. I continued to put up formwork and as a further precaution against bowing in the centre I put an extra spacer and coach screw in the centre of each sheet of formwork and to prevent creating difficult areas to tamp I put the spacers and screws further in from the corners.   

Two test sections of hemp wall done and formwork moved up
This section of wall was made with one mix
I have also made peace with the surveyors after they did not carry out the house set out survey properly. They refunded me the extra cost I had to pay for the extra concrete piers and have offered to do a final survey at no cost. This final survey is likely to be necessary to prove to council that the house is still with in the required set backs, even though it is not in the location specified on the Council approved plans.

26 comments:

  1. The plumbing system looks great. Using cross linked polyethylene pipes is definitely smart since these pipes offer multiple benefits. For instance, polyethylene pipes are very lightweight. This means installation is going to be pretty easy. Also, the pipes are highly resistant to corrosion and abrasion, and this means you won’t have to worry too much about having broken pipes jacking up your water bill in the future.

    ReplyDelete
  2. How’s your plumbing system? I hope that these pipes are still doing well. Polyethylene pipes are known for its flexibility, strength and durability. You just have to make sure that your pipes are not exposed to direct sunlight to avoid corrosion and damage.

    ReplyDelete
  3. It does look great, Bibi! Aside from the advantage that you've said about polyethylene pipes, they can also resist corrosion and they’re flexible. With this you don't have to worry about the pipes swelling or dissolving, when using solvents to remove the debris inside your pipelines.

    ReplyDelete
  4. Great write-up, I am a big believer in commenting on blogs to inform the blog writers know that they’ve added something worthwhile to the world wide web!.. Construction bids

    ReplyDelete
  5. This type of message always inspiring and I prefer to read quality content, so happy to find good place to many here in the post, the writing is just great, thanks for the post. Plumbing Services in Spicewood TX

    ReplyDelete
  6. I wanted to thank you for this excellent read!! I definitely loved every little bit of it. I have you bookmarked your site to check out the new stuff you post. Emergency Plumber Toronto

    ReplyDelete
  7. Why you use copper? PE X & XLPE much better!

    ReplyDelete
  8. I am unable to read articles online very often, but I’m glad I did today. This is very well written and your points are well-expressed. Please, don’t ever stop writing.
    burbank plumber

    ReplyDelete
  9. Thank you very much for writing such an interesting article on this topic. This has really made me think and I hope to read more. plumbing Singapore

    ReplyDelete
  10. It is perfect time to make some plans for the future and it is time to be happy. I've read this post and if I could I desire to suggest you some interesting things or suggestions. Perhaps you could write next articles referring to this article. I want to read more things about it! Minor Plumbing Services in San Ramon CA

    ReplyDelete
  11. Great job for publishing such a beneficial web site. Your web log isn’t only useful but it is additionally really creative too. There tend to be not many people who can certainly write not so simple posts that artistically. Continue the nice writing electric water heater

    ReplyDelete
  12. Fabulous post, you have denoted out some fantastic points, I likewise think this s a very wonderful website. I will visit again for more quality contents and also, recommend this site to all. Thanks. Plumbing cardiff

    ReplyDelete
  13. Wow i can say that this is another great article as expected of this blog.Bookmarked this site.. sửa chữa nhà trọn gói

    ReplyDelete
  14. Wonderful article. Fascinating to read. I love to read such an excellent article. Thanks! It has made my task more and extra easy. Keep rocking. home repipe specialist Vista

    ReplyDelete
  15. Great article Lot's of information to Read...Great Man Keep Posting and update to People..Thanks Las Vegas

    ReplyDelete
  16. I felt very happy while reading this site. This was really very informative site for me. I really liked it. This was really a cordial post. Thanks a lot!. brushing a golden retriever

    ReplyDelete
  17. Pretty good post. I just stumbled upon your blog and wanted to say that I have really enjoyed reading your blog posts. Any way I'll be subscribing to your feed and I hope you post again soon. Big thanks for the useful info. Oklahoma Cannabis

    ReplyDelete
  18. Thanks for a very interesting blog. What else may I get that kind of info written in such a perfect approach? I’ve a undertaking that I am simply now operating on, and I have been at the look out for such info. painting company New lenox

    ReplyDelete
  19. Buy heroin online Canna Pure Pharmacycanna pure pharmacy is known as McDonald’s of the cannabis industry. The American online distributor of marijuana (buy weed online USA, buy weed online Canada), hash oil for sale,buy edibles online and THC extracts accepts Bitcoin. Even in a legalized marijuana state, mail order marijuana | CANNA PURE PHARMACY

    ReplyDelete
  20. Nice Read and Good Job Len the plumber,
    Regards Ian King

    ReplyDelete
  21. Pretty good post. I just stumbled upon your blog and wanted to say that I have really enjoyed reading your blog posts. Any way I'll be subscribing to your feed and I hope you post again soon. Big thanks for the useful info. singapore interior design

    ReplyDelete
  22. Thank you for taking the time to publish this information very useful! singapore renovation

    ReplyDelete
  23. Nice!! If you want coach screw supplier in Australia. Then Contact Mig Enterprises. I bought screws, nails, nuts, bolts so many times from there and they are the best. Always gives the best services.

    ReplyDelete
  24. A very awesome blog post. We are really grateful for your blog post. You will find a lot of approaches after visiting your post. PPR pipe

    ReplyDelete
  25. Excited to glean insights from the blog and possibly apply them to my own plumbing endeavors. If there are any specific aspects or techniques highlighted, I'd love to hear more about them.

    ReplyDelete
  26. Need a plumber in Toronto? We've got you covered! Our experienced team offers fast, reliable service for all your plumbing needs. From repairs to installations, we're here to keep your home or business running smoothly.

    ReplyDelete